Dodge Cummins
The Edge Comp module maximizes engine efficiency by monitoring the RPM, timing, turbo boost pressure and fueling parameters. The module uses this information to determine and control both fueling and timing enhancements for the Bosch fuel injection pump. Timing and fueling enhancements are controlled via CAN-BUS through the Data Link and by connecting directly into the Bosch fuel injection pump.
The Edge Comp features five power levels with power gains from 40-120 horsepower. Each of the five power levels has an independent five-level adjustable responsiveness setting, providing for a total of 25 levels of adjustability! The responsiveness settings enable you to dial-in the optimum balance between responsiveness and low boost smoke control, no matter what additional power modifications have been made to the engine. The Comp module is fully adjustable on the fly and mounts inside the cab.
Sub-levels 1-3 on the Comp will provide de-fueling below stock. The de-fueling mode is entered only when rpm and boost are below a set value and stock fueling is being increased beyond a set rate. These conditions are different for each sub-level 1-3. During operation, when the de-fueling mode is entered, the rate of fueling increase is limited, which reduces smoke. De-fuel mode is exited once stock fueling equals the fueling controlled by the Comp. This way the transition is smooth and cannot be felt while driving. De-fuel mode is entered the easiest in sub-level 1 and has the smallest allowable fuel increase, while sub-level 3 de-fuel mode is not entered as easily and has a larger allowable fuel increase.
Sub-levels 4 and 5 allow adjustment of the additional fueling above stock based on boost level. Sub-level 5 adds the most fuel at low boost; Sub-level 4, which adds less fuel than Sub-level 5, corresponds to jumper setting 2 on the EZ.
The amount of additional fuel added is calculated, the amount actually added after being compared to boost from the total is as shown below:
Sub level 1: 33% is added at 0 psi boost
100% is added at 20 psi boost
Sub level 2: 50% is added at 0 psi boost
100% is added at 15 psi boost
Sub level 3: 67% is added at 0 psi boost
100% is added at 10 psi boost
Fuel may be added at 0 psi boost on all Sub Levels and EZ Jumper settings unless the de-fuel mode is entered as described above.
Power Level 1 on the Comp is the same as the EZ; on Power Levels 2-5 additional power is added via the wire tap onto the injection pump. If the pump wire is not attached with a Comp, Levels 2-5 are still operational, but the power gain is not any higher than Level 1. Under this scenario, however, power will come on much earlier in the throttle.
**Legal in California only for racing vehicles which may never be used upon a highway.
30300 |
COMP Dodge 98.5-2000 |
$559.20 |
 |
30301 |
COMP Dodge 2001-2002 |
$559.20 |
|
The Power Edge EZ is a plug-in module that maximizes engine efficiency by monitoring the RPM, timing, turbo boost pressure and fueling parameters. The module uses this information to determine and control both fueling and timing enhancements for the Bosch fuel injection pump. The re-mapping of the fueling and timing parameters is done via the CAN-BUS communication system. The CAN-BUS protocol is used to communicate between the Cummins Engine Control Module (ECM) and the Bosch fuel injection pump. All data sent from the EZ is within the limits of the Bosch fuel injection pump. This enables smooth and predictable power delivery without compromising integrity. This increase in power does not increase the exhaust smoke from a stock engine.
The Edge EZ allows maximum fueling at full turbo boost and provides an additional 65-rear wheel horsepower, an additional 185 foot pounds of torque and installs in minutes. Simply plug the EZ connectors into the ECM Data Link connection and MAP sensor. There’s no need to unplug the Bosch fuel injection pump connector, it is completely weatherproof and mounts easily under the hood.
30200 |
EZ Dodge 98.5-2000 |
$439.20 |
|
30201 |
EZ Dodge 2001-2002 |
$439.20 |
|
30203 |
EZ Dodge 2003-04 CR |
$415.20 |
|
30204 |
EZ Dodge 04.5-05 CR |
$479.20 |
|
The Edge Juice/Attitude is a highly sophisticated package capable of dramatically improving your Cummins’ driveability, towing, mileage and, most importantly, POWER.
Using factory-style connections in just ten minutes you can add five levels* of adjustable power ranging from 40 to 100 horsepower – and increase torque up to 250 ft. lbs. The Juice greatly improves responsiveness and driveability, while at the same time increasing fuel economy.
When used in conjunction with the Attitude monitor you can control the five power levels on-the-fly from inside your truck. The Attitude displays all the information a complete set of gauges would and will automatically monitor and display exhaust gas temperature (EGT), turbo boost and transmission slip and de-fuel the engine to prevent excessive EGT, boost levels or transmission slippage. It also displays 0 – 60 times, quarter mile times and actual speed if you are using non-stock tires as well as a host of other parameters.
The following power gains are representative of a 5.9 Dodge Cummins (600 Series) equipped with the Juice module with Attitude monitor: 
Level 0: Stock
Level 1: 25 Horsepower - 80 Foot Pounds of Torque
Level 2: 40 Horsepower - 120 Foot Pounds of Torque
Level 3: 60 Horsepower - 150 Foot Pounds of Torque
Level 4: 80 Horsepower - 200 Foot Pounds of Torque
Level 5: 100 Horsepower - 250 Foot Pounds of Torque
Imagine, within minutes you get incredible power gains, an increase in mileage and the equivalent of a complete set of gauges with one simple installation!
The Juice communicates directly with the engine’s ECM, from which it receives vital engine and fuel system information. This enables the Juice to provide smooth and precise power in real time under any driving condition.
**Legal in California only for racing vehicles which may never be used upon a highway.
30003 |
Juice 03-04 Dodge CR |
$599.20 |
|
30103 |
Juice W/Attitude Monitor 03-04 Dodge CR |
$799.20 |
|
30004 |
Juice 04.5-05 Dodge CR |
$599.20 |
|
30104 |
Juice W/Attitude Monitor 04.5-05 Dodge CR |
$799.20 |
|
33001 |
Attitude Monitor 03-04 Dodge |
$239.20 |
|
33002 |
Attitude Monitor 04.5-05 Dodge 600 Series |
$239.20 |
|
38402 |
Attitude Pillar 03+ |
$60.00 |
|
Jammer injector nozzle for Cummins engines. These "Jammer" nozzles have been designed for the 1998.5-2002 5.9L Cummins ISB engines in Dodge Ram trucks and RV coaches. The proprietary process used to vent these injector nozzles intricately machines 8 orifices into the tips. Compared to the stock 7-orifice injectors. Jammers feature better atomization, faster fuel flow and enhanced spray angle. The increased number of orifices enables the injectors to deliver more fuel while still maintaining proper fuel pressure. Improved combustion-chamber cleanliness.
Improve fuel economy by up to 1.5 mpg depending on individual driving style.
Jammers offer incredible value to the consumer with the same performance as a full set of injectors, since the use of the Truck's existing injector bodies are reused.
Installation is recommended by a certified fuel shop, a pop off checker is required.
37001 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 1 |
$172.80 |
|
37002 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 2 |
$201.60 |
|
37003 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 3 |
$220.80 |
|
37004 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 4 |
$240.00 |
|
37005 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 5 |
$259.20 |
|
The proprietary process used to vent these injector nozzles intricately machines 8 orifices into the tips. Compared to the stock 7-orifice injectors.
Jammers feature better atomization, faster fuel flow and enhanced spray angle.
The increased number of orifices enables the injectors to deliver more fuel while still maintaining proper fuel pressure.
Improved combustion-chamber cleanliness.
Improve fuel economy by up to 1.5 mpg depending on individual driving style.
Jammers offer incredible value to the consumer with the same performance as a full set of injectors, since the use of the Truck's existing injector bodies are reused.
03-04 DODGE
Installation is recommended by a certified fuel shop, a pop off checker is required.
37006 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 1 |
$640.00 |
|
37007 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 2 |
$700.00 |
|
37008 |
6 SET INJECTOR NOZZLE SYSTEM - STAGE 3 |
$760.00 |
|
|
